Subaru Outback 2002 - Vehicle speed control



Table of contents:
Subaru Outback 2002 recalls
CampaignManufacturerManufacturing dateType# of units affectedDate Owner notified MfgRecall Initiated byManufacturers of recalled vehicles/productsReport Recieved DateRecord Creation DateRegulation Part NumberFMVSS Number
VEHICLE SPEED CONTROL - CABLES
04V128000SUBARU OF AMERICA, INC.from 03/15/2000 to 02/19/2004V (Vehicle)12758004/12/2004MFRSUBARU OF AMERICA, INC.03/16/200403/22/2004
Defect SummaryOn certain passenger sedans, wagons, and sport utility vehicles, the cruise control cable could come out of its track on the cruise control lever and lodge on the control lever tab when the accelerator pedal is released. if this condition occurs, the throttle will not return to the idle position and will remain in an open position.
Consequence SummaryIf this occurs during vehicle operation, the driver could lose control of the vehicle, which could result in a crash.
Corrective SummaryDealers will install a cruise control cable retaining clip to the cruise control lever tab on the throttle shaft in order to prevent the cruise control cable from coming out of its track. owner notification began on april 12, 2004. owners should contact subaru at 1-800-782-2783.
NotesSubaru recall no. wwq-01.customers can also contact the national highway traffic safety administration
Subaru Outback 2002 bulletins
BulletinBulletin dateReplacement BulletinItem no.SummaryAdded
VEHICLE SPEED CONTROL - CABLES
03100403/10/200410006827Immediate stop sale order for possible cruise control cable mislocation that could prevent the throttle from closing. *tt2004-05-14
VEHICLE SPEED CONTROL - CRUISE CONTROL
0103/01/200410006814Cruise control cable retaining clip. *tt2004-05-14
Subaru Outback 2002 Consumer Complaints
Fail datemilesoccurencesPurchase date
VEHICLE SPEED CONTROL
05/09/201071000
 Tl* the contact owns a 2002 subaru outback. while attempting to shift into park, the vehicle abnormally accelerated without warning, causing the contact to crash into a nearby fence. the contact was not injured. the vehicle was not taken to the dealer for further testing to determine the cause of the failure. the failure and current mileages were 71,000.
05/14/200643000201/04/2002
 Just started car and pulled up to stop light and hit break pedal. all of a sudden there was a sudden acceleration and the car started forward and i had to lean on the break very hard to stop. this occurred 2 times both after starting the car after at least a 1 hour off time. i thought at first it was my foot on both pedals but the second time i stopped the car with my left foot and was nowhere near the accelerator. i contacted subaru but they denied any problem. i put if off until i saw an article in st louis post dispatch to letters to tom and ray magliozzi the car guys and the letter was from another subaru outback owner with the same problem. *nm
06/02/200547888205/11/2002
 2002 subaru outback wagon has 48,000 miles. car stalls at red lights, sputters and hesitates when trying to accelerate from a stop. dangerous trying to get on highway. dealer tested all systems and said nothing was wrong with the car. independent mechanic tested it and said main computer not working properly. check engine light never came on. mechanic reset computer but suggested i get rid of the car asap
09/25/200444500209/22/2001
 The engine began to idle roughly quite a few months prior (dealer unable to detect any problem), subsequently experienced hesitation from stop; progressed to fluctuating idle speed from 750 to 500 rpm with self correction to 750 after car had been driven and fully warmed up which progressed to episode of hesitation while driving up hill with near engine stall. thereafter had a few episodes of engine surging while stopping in drive, which did not stop when put into either neutral or park (dealer unable to diagnose any problem, did software replaced but problem continued to degenerate). engine stalled when it came to stop then when restarted continued to have surging as above described. engine would have hesitation and near stall also during regular operation on highway even at cruising speeds from 20 mph to 65 mph. dealer currently attempting to diagnose problem again.*ak
02/25/20031
 The vehicle experienced sudden acceleration.*jb
09/21/2002109/28/2001
 The consumer states that while pulling into a parking space, the vehicle went into full throttle resulting in a crash. the cause is unknown. *nlm *scc
10/01/2001
 Engine stalls on acceleration from a stop. at times the engine will die when accelerator is pressed. dealer was contacted and vehicle taken to dealer. dealer states that there are numerous vehicles which have the same problem. all of them are 2002 models. dealer states tha tvehicle cannon be fixed at this time due to a lack of knowledge of what to do. this occured the first week of august 2002. dealer was contacted on september 5, 2002 and stated that vehicle still could not be repaired due to lack of knowledge. dealer stated that the engineers in japan were working on the problem but it will be at least two more months before it would be known what if anything could be done.*ak
VEHICLE SPEED CONTROL - ACCELERATOR PEDAL
06/26/2007112/01/2002
 I pressed the gas pedal to accelerate around a corner and when i eased off the gas pedal it remained stuck down. i put the car in neutral and braked so i could pull over. i shut off the car, and when i restarted it, the engine revved . i had to put my foot under the gas pedal and lift it up to resolve the problem.*ak
03/11/2005410003
 Vehicle experienced sudden acceleration. owner was pulling into a school parking lot when suddenly the vehicle began to accelerate. the engine revved, and the driver had both feet on the brake while the vehicle continued to accelerate. driver put the vehicle in neutral, and allowed the vehicle to coast before it shut down.*ak
12/03/20043120075
 Dangerous hesitation in first and second gears especially. at stop light, upon attempting to accelerate, car bogged down, rpms dipped and nearly stalled before car finally accelerated with a violent jerk forward and back. has happened on numerous occasions. very dangerous-nearly been in three accidents already. so far the dealer has bled the clutch, adjusted the clutch, replaced the clutch, replaced knock sensor, replaced coolant temp sensor and replaced front oxygen sensor and problem still as bad as ever if not worse. *jb
1
 When applying pressure to the accelerator pedal vehicle would jerk and experience sudden deceleration. when removing pressure from the accelerator pedal the vehicle stalls. dealer indicates this is normal for this type of vehicle, and there is no a remedy for this problem. *ak